Subaru Crosstrek Service Manual: Inspection

Subaru Crosstrek Service Manual / Fuel injection (fuel systems)(h4do) / Throttle body / Inspection

FUEL INJECTION (FUEL SYSTEMS)(H4DO) > Throttle Body

INSPECTION

1. THROTTLE SENSOR (METHOD WITH CIRCUIT TESTER)

1. Remove the glove box. Glove Box > REMOVAL">

2. Turn the ignition switch to ON. (engine OFF)

3. Measure the voltage between ECM connector terminals.

(A)

To ECM connector

Throttle sensor	Accelerator pedal	Terminal No.	Standard
Main	Not depressed (full closed)	18 (+) and 29 (−)	Approx. 0.6 V
Main	Depressed (full opened)	18 (+) and 29 (−)	Approx. 4.0 V
Sub	Not depressed (full closed)	28 (+) and 29 (−)	Approx. 1.5 V
Sub	Depressed (full opened)	28 (+) and 29 (−)	Approx. 4.2 V

4. After inspection, install the related parts in the reverse order of removal.

2. THROTTLE SENSOR (METHOD WITH SUBARU SELECT MONITOR)

1. Turn the ignition switch to ON. (engine OFF)

2. Read the throttle opening angle signal and voltage of throttle sensor using Subaru Select Monitor. Subaru Select Monitor > OPERATION">

Throttle sensor	Throttle opening angle signal	Standard
Main	0.0%	Approx. 0.6 V
Main	100.0%	Approx. 4.0 V
Sub	0.0%	Approx. 1.5 V
Sub	100.0%	Approx. 4.2 V

3. OTHER INSPECTIONS

1. Check that the throttle body has no deformation, cracks or other damages.

2. Check that the preheater hose has no cracks, damage or loose part.

Removal

FUEL INJECTION (FUEL SYSTEMS)(H4DO) > Throttle BodyREMOVAL1. Disconnect the ground cable from battery.2. Lift up the vehicle.3. Remove the under cover. Front Under Cover > REMOVAL">4. D ...

Other materials:

Removal
BRAKE > Rear Brake PadREMOVAL1. Lift up the vehicle, and then remove the rear wheels.2. Remove the rear brake pad.(1) Remove the bolts and remove the brake hose bracket.(2) Remove the caliper bolt, and raise and hold the caliper body assembly.NOTE:Do not disconnect the brake hose from the caliper ...

Dtc p0353 ignition coil "c" primary control circuit/open
ENGINE (DIAGNOSTICS)(H4DO) > Diagnostic Procedure with Diagnostic Trouble Code (DTC)DTC P0353 IGNITION COIL "C" PRIMARY CONTROL CIRCUIT/OPENNOTE:For the diagnostic procedure, refer to DTC P0351. Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P0351 IGNITION COIL " ...

Dtc p0400 egr "a" flow
ENGINE (DIAGNOSTICS)(H4DO) > Diagnostic Procedure with Diagnostic Trouble Code (DTC)DTC P0400 EGR "A" FLOWDTC detecting condition:Detected when two consecutive driving cycles with fault occur.Trouble symptom:• Movement performance problem when engine is low speed• Improper i ...