Subaru Crosstrek Service Manual: Dtc p1451 evap system clog detected (pipe)

DTC DETECTING CONDITION:

Detected when two consecutive driving cycles with fault occur.

CAUTION:

After servicing or replacing faulty parts, perform Clear Memory Mode Clear Memory Mode > OPERATION">, and Inspection Mode Inspection Mode > PROCEDURE">.

1.CHECK DRAIN TUBE BETWEEN CANISTER AND LEAK CHECK VALVE ASSEMBLY.

Is the drain tube between canister and leak check valve assembly clogged?

Replace the drain tube between the canister and leak check valve assembly. Canister">

Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P1451 EVAP SYSTEM CLOG DETECTED (PIPE)">Go to Step 2.

2.CHECK HOSES BETWEEN CANISTER AND FUEL TANK.

Are the hoses between the canister and fuel tank clogged?

Replace the hoses between the canister and fuel tank. Canister"> Fuel Tank">

Replace the canister. Canister">

After the operation is complete, go to the next step. Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P1451 EVAP SYSTEM CLOG DETECTED (PIPE)">Go to Step 3.

3.CHECK EVAPORATIVE EMISSION CONTROL SYSTEM.

Perform drive cycle I. Drive Cycle > PROCEDURE">

Is DTC P1451 displayed on the display?

Replace the leak check valve assembly. Leak Check Valve Assembly">

End.

For the detection standard, refer to DTC P0455. Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P0455 EVAP SYSTEM (CPC) LEAK DETECTED (LARGE LEAK)">

Dtc p1449 evap system clog detected (air filter)

Dtc p1492 coil 1 egr "a" control circuit low

Other materials:

Inspection
DRIVE SHAFT SYSTEM > Rear Drive ShaftINSPECTIONCheck the removed parts for damage, wear, corrosion etc. Repair or replace if defective.• DOJ (Double Offset Joint):Check for seizure, corrosion, damage, wear and excessive play.• BJ (Bell Joint):Check for seizure, corrosion, damage and e ...

Dtc p1497 coil 3 egr "a" control circuit high
ENGINE (DIAGNOSTICS)(H4DO) > Diagnostic Procedure with Diagnostic Trouble Code (DTC)DTC P1497 COIL 3 EGR "A" CONTROL CIRCUIT HIGHNOTE:For the diagnostic procedure, refer to DTC P1499. Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P1499 COIL 4 EGR "A" CONTRO ...

Adjustment
MANUAL TRANSMISSION AND DIFFERENTIAL(5MT) > Main Shaft AssemblyADJUSTMENTSelection of main shaft rear plate:Measure the protrusion amount (A) of ball bearing from transmission main case surface, and select a suitable plate in the following table.NOTE:Before measuring, tap the end of main shaft wi ...