Subaru Crosstrek Service Manual: Dtc b1435 evaporator temperature sensor circuit short-circuit

DTC detecting condition:

Evaporator sensor circuit is shorted.

Trouble symptom:

Evaporator temperature is falsely recognized as high, and the compartment temperature is adjusted.

Wiring diagram:

Air conditioning system Air Conditioning System > WIRING DIAGRAM">

1.CHECK CONNECTOR.

1) Check the condition of connector connection.

2) Read the DTC using Subaru Select Monitor. Read Diagnostic Trouble Code (DTC)">

Is B1435 displayed?

Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC B1435 EVAPORATOR TEMPERATURE SENSOR CIRCUIT SHORT-CIRCUIT">Go to Step 2.

Even if DTC is displayed, the circuit has returned to a normal condition at this time. Reproduce the failure, and then perform the diagnosis again.

NOTE:

In this case, temporary poor contact of connector, temporary open or short circuit of harness may be the cause.

2.CHECK EVAPORATOR SENSOR.

1) Disconnect the evaporator sensor.

2) Read the DTC using Subaru Select Monitor. Read Diagnostic Trouble Code (DTC)">

Is B1434 displayed?

Replace the evaporator sensor. Evaporator > REMOVAL">

Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC B1435 EVAPORATOR TEMPERATURE SENSOR CIRCUIT SHORT-CIRCUIT">Go to Step 3.

3.CHECK HARNESS.

1) Turn the ignition switch to ON.

2) Using the tester, measure the voltage between terminals.

Connector & terminal

(B88) No. 2 (+) — No. 1 (–):

Is the voltage 4.5 — 5.0 V?

Even if DTC is displayed, the circuit has returned to a normal condition at this time. Reproduce the failure, and then perform the diagnosis again.

NOTE:

In this case, temporary poor contact of connector, temporary open or short circuit of harness may be the cause.

Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC B1435 EVAPORATOR TEMPERATURE SENSOR CIRCUIT SHORT-CIRCUIT">Go to Step 4.

4.CHECK HARNESS (SHORTED BETWEEN LINES).

1) Disconnect the connector from the A/C control panel.

2) Using a tester, check continuity between terminals.

Connector & terminal

(B88) No. 1 — No. 2:

Is there continuity?

Repair or replace the short circuit of the harness.

Replace the A/C control panel. Control Panel > REMOVAL">

Dtc b1434 evaporator temperature sensor circuit open

Dtc b14a1 sunload sensor circuit low/open

Other materials:

Dtc p0128 coolant thermostat (engine coolant temperature below thermostat regulating temperature)
ENGINE (DIAGNOSTICS)(H4DO) > Diagnostic Procedure with Diagnostic Trouble Code (DTC)DTC P0128 COOLANT THERMOSTAT (ENGINE COOLANT TEMPERATURE BELOW THERMOSTAT REGULATING TEMPERATURE)DTC detecting condition:Detected when two consecutive driving cycles with fault occur.Trouble symptom:• Thermo ...

Removal
CONTINUOUSLY VARIABLE TRANSMISSION(TR580) > CVTF Cooler (With Warmer Function)REMOVALCAUTION:If the CVTF and engine coolant is spilt over exhaust pipe, wipe it off with cloth to avoid emitting smoke or causing a fire.1. Disconnect the ground cable from battery. NOTE">NOTE:For model with ...

Dtc p0171 system too lean bank 1
ENGINE (DIAGNOSTICS)(H4DO) > Diagnostic Procedure with Diagnostic Trouble Code (DTC)DTC P0171 SYSTEM TOO LEAN BANK 1Refer to DTC P0172 for diagnostic procedure. Diagnostic Procedure with Diagnostic Trouble Code (DTC) > DTC P0172 SYSTEM TOO RICH BANK 1">1. OUTLINE OF DIAGNOSISDetect fu ...