Subaru Crosstrek Service Manual: Disassembly
MANUAL TRANSMISSION AND DIFFERENTIAL(5MT) > Transfer Case and Extension Case Assembly
DISASSEMBLY
1. TRANSFER CASE
1. Remove the reverse check sleeve assembly. Reverse Check Sleeve > REMOVAL">
2. Remove the oil guide.
3. Remove the oil seal.
4. Set ST1, ST2 and transfer case to a press.
NOTE:
• Set the ST2 under ST1.
• Set the transfer case so that the hole for shifter arm is positioned vertically.
| ST1 498267300 | CYLINDER HEAD TABLE |
| ST2 498267200 | CYLINDER HEAD TABLE |
5. Using the round bar with diameter of 22 mm (0.87 in) or 23 mm (0.91 in), remove the roller bearing.
2. EXTENSION CASE
1. Remove the transfer drive gear assembly. Transfer Drive Gear > REMOVAL">
2. Remove the shift bracket.
3. Remove the oil seal from the extension case. Oil Seal">
4. Remove the dust cover.
Removal
MANUAL TRANSMISSION AND DIFFERENTIAL(5MT) > Transfer Case and Extension Case AssemblyREMOVAL1. Remove the manual transmission assembly from the vehicle. Manual Transmission Assembly > REMOVAL&q ...
Installation
MANUAL TRANSMISSION AND DIFFERENTIAL(5MT) > Transfer Case and Extension Case AssemblyINSTALLATION1. Clean the mating surfaces of the transmission case, transfer case and extension case.2. Apply a c ...
Other materials:
Removal
SEATS > Seat Heater SystemREMOVAL1. SEAT HEATER UNIT1. Remove the front seats. Front Seat > REMOVAL">2. Remove the backrest cover of front seat and seat cushion cover. Front Seat > DISASSEMBLY">3. Remove the seat heater module.CAUTION:If the seat heater module is removed, ...
Diagnostics with phenomenon Inspection
Blind Spot Detection/Rear Cross Traffic Alert (DIAGNOSTICS) > Diagnostics with PhenomenonINSPECTIONSymptomsMaintenance partsBSD/RCTA does not operate.FuseLAN system Basic Diagnostic Procedure">Body control system Basic Diagnostic Procedure">Radar sensor LHRadar sensor RHBSD/RCTA ...
Control unit Note
EyeSight > Control UnitNOTESystem control of the EyeSight is performed by each module. For procedure, refer to the following sections.• Engine control module (ECM): Engine Control Module (ECM)">• Transmission control module (TCM): Transmission Control Module (TCM)">& ...
